View Full Version : Kennedy Space Center: NASA invites public to tour its Vehicle Assembly Building

25-10-2011, 08:49 AM
With no more space shuttles to build up for launch and years to go before its next-generation heavy-lift rocket is ready to fly, NASA is reopening its 52 story Vehicle Assembly Building to the public after more than three decades of it being closed for general tours.

Beginning next month, visitors to NASA's Kennedy Space Center in Florida will be able to purchase tickets for a new "Up-Close" tour, which in addition to busing spectators to see launch pads and other facilities around the spaceport, will take them in the Vehicle Assembly Building, or VAB.

The huge building the largest single-story structure and the fourth largest by volume in the world was used for 30 years to stack shuttle orbiters with their boosters and fuel tanks for 135 missions. Before then, the building's original use was to assemble the stages that formed the 363-foot Saturn V rockets that launched Apollo astronauts to the moon.


The building, its side adorned with a painted U.S. flag so large that a city bus could fit within any one of its red and white stripes, has attracted tourists since it was built in 1966. But since 1978, spectators have had to settle for an outside view only as the solid fuel in the shuttle's boosters made the building too dangerous to allow in large groups of visitors.

With the shuttle program over, the Kennedy Space Center Visitor Complex (KSCVC) is now able to offer limited daily tours to bring their guests into the VAB.

Shuttle sighting

Once inside the 525-foot tall Vehicle Assembly Building, tour-goers will walk along the edge of the transfer aisle, a 700-foot long corridor that divides the voluminous hangar's north and south sides. The aisle was used to move the behemoth segments of Saturn rockets and space shuttles among the four high bays within the building.

It is within one of these high bays that some visitors may still spot one of NASA's retired shuttles waiting inside the VAB to be readied for its public display.

With three orbiters to prepare Discovery, Endeavour and Atlantis and only two operational processing facilities, the space center has taken to temporarily parking one of the shuttles in the VAB. At current, Endeavour is inside High Bay 4, but it is expected to trade places with another orbiter soon.


Beginning next year, NASA will start shipping the orbiters out to their respective museums, with Discovery slated as the first to leave in April. The shuttle encounter inside the VAB will therefore be available for a limited time only.

Signs of things to come

Even without the rare shuttle sighting, spectators will find plenty to see inside the building.

Tour guides will provide overviews of the the work done in the VAB, and colorful signage will offer tourists a view of the past engineering feats that have taken place behind the 456-foot-tall high bay doors, such as the work of the building's two 325-ton bridge cranes that were used to lift the shuttle orbiters and mate them to their external tank and boosters with pinpoint accuracy.

Visitors will also preview the planned operations that will take place in the coming years to support NASA's next space exploration program, the Space Launch System, or SLS. The Congressionally-authorized heavy-lift rocket and its multi-purpose crew vehicle (MPCV) which when fully assembled will tower as tall, if not taller than the Saturn V is being developed to launch astronauts on exploration missions out into the solar system.

Outside the VAB

Going inside of the Vehicle Assembly Building may be the highlight of the new "KSC Up-Close" bus tour, but it is not its only stop.

Set to begin Nov. 1 and run eight times daily, the tour will begin with guests seeing other KSC landmarks including the center headquarters and the Operations and Checkout (O&C) building, which houses the astronaut crew quarters used prior to each launch and where space hardware was tested before flight. The O&C is also the site from which astronauts boarded the Astrovan for the launch pads.

The tour will also drive by the Space Station Processing Facility, where the components that fit together in orbit to build the International Space Station were processed and tested before launch.

Next, guests will be taken to the NASA Causeway for a panoramic view of the Banana River, Port Canaveral and Cape Canaveral Air Force Station, home of the first rocket launches for 1960's Mercury and Gemini programs. Tour participants will be able to spot launch pads 17, 37, 40, and 41, which are still in use for both commercial and government launches. They may even spot rockets on the pads or inside their mobile service structures.

From this vantage point, spectators may also see Liberty Star and Freedom Star, the two recovery ships used to retrieve the space shuttle's reusable solid rocket boosters from the Atlantic Ocean after they were jettisoned during each launch.

Crawlers, the countdown clock and more

The tour will then travel past the three orbiter processing facilities (OPFs), the hangars where shuttle orbiters were processed and maintained between flights. Today, two of the OPFs are being used to decommission the orbiters in preparation for their retirement, including Atlantis, which will be displayed in a $100 million facility at the Kennedy Space Center Visitor Complex in 2013.

Following a stop inside the VAB, tour-goers will re-board their bus for views of the massive crawler transporters and "crawlerway," the equivalent of an eight-lane highway lined with river rock and designed to support the crushing weight of the Saturn V and space shuttles along with their mobile launch platforms.

They'll also get a view of the solid rocket booster storage areas; the Pegasus barge used to haul shuttle external tanks from their assembly facility in Louisiana; the NASA Press Site with its iconic large countdown clock; as well as the Shuttle Landing Facility (SLF) and its Mate/Demate Device, where orbiters were unloaded from Boeing 747s after an occasional cross-country piggyback ride.

Finally, the tour will give guests the chance to see Launch Pads 39A and 39B from one of the hilltop sites from which NASA remotely captured launch imagery.

Ticket to ride

The two-hour "KSC Up-Close" tour, which is one of two special-interest tours being offered by the Kennedy Space Center Visitor Complex, will require an additional ticket to ride.

The new tour with its access inside the Vehicle Assembly Building will run visitors $25 per adult and $19 for children (ages 3-11), in addition to the normal cost of admission to the Visitor Complex.

Due to the anticipated popularity of the new tour, Visitor Complex officials advise that advance reservations are "strongly suggested."

To book the Up-Close tour, visit kennedyspacecenter.com or call 866-737-5235

25-10-2011, 08:50 AM
I hope this is still running next September/October :fingers:

25-10-2011, 03:34 PM
That`s a great addition at KSC. :yes:
I`ve always wanted to see inside the VAB and half expected to be taken there when I did the Astronaut Training Experience, however the place was out of bounds to everyone at the time.

25-10-2011, 03:51 PM
I thought of you when I posted it Terry :D It's supposed to be for a limited time, so you'd better hurry up and get a trip booked.

I really hope its still open when we go next year :fingers:

25-10-2011, 05:16 PM
That`s a great addition at KSC. :yes:
I`ve always wanted to see inside the VAB and half expected to be taken there when I did the Astronaut Training Experience, however the place was out of bounds to everyone at the time.

ME TOO!!! :yes:

25-10-2011, 06:07 PM
ME TOO!!! :yes:

:mental: Keith, buy your tickets now, you can go when you are over there, I think Kennedy was in the way points I sent you :D

25-10-2011, 06:59 PM
Hope it doesn't rain. :fingers:

Inside. :mental:

The buildings large enough to have it's own internal weather system. Course it really doesn't rain in there since the moisture control system removes the moisture before that happens. But rain clouds do form inside on humid days.

Tom (:macwave:... I used to spend some time down there as a vendor.)

25-10-2011, 07:32 PM
I could get so darned excited by seeing a building :lol: but I should see if I can book first I guess :unsure: It would also give me another opportunity to buy more NASA jackets so I can pretend :P and of course if that millions of years old asteroid fragment is still there, that's an essential... and...... :)

28-10-2011, 04:14 PM
It would also give me another opportunity to buy more NASA jackets )
I was on the verge of buying one of those a few years ago Keith.
What put me off was the fact that the darned thing was made in the Far East!!!
I found this amazing when you think that there are fewer places than KSC that are America through and through. :unsure:

28-10-2011, 04:31 PM
I found this amazing when you think that there are fewer places than KSC that are America through and through. :unsure:

Isn't it amazing!

Made in America used to be a slogan we wore with pride. Sadly no more. Personally, I think it's just pitiful.

Tom (:macwave:... NOT made in China!)

28-10-2011, 04:41 PM
:yes: completely agree, the good old days have long gone sadly :(

Blimey I sound like I'm a 100 :lol: :lol:

29-10-2011, 11:16 AM
"Look for the Union label when you are buying a coat, dress or blouse..." Remember that commercial?

"Hey, hey, hey whaddaya' say? It was made in the USA!" I remember little kids chanting that for Pete's sake...

At any rate, KSC is looking for any way to bring in revenue now. :sigh:

Tom, I can't imagine how big that building must be to form its own clouds?! :eek: